搅拌车不能转动我们需要怎么处理？_行业新闻_新闻资讯_全自动上料搅拌机车

新闻资讯

行业新闻公司新闻

热点推荐

自动上料搅拌机配件是由哪两部分组成的？

2022-12-23

修路有哪些不错的机械设备？先说说这个小型搅拌车

2022-12-19

自上料搅拌车操作须知的五项重要内容

2022-12-16

自上料拌和车的特征有哪些？

2022-12-12

自动上料搅拌车能解决哪些施工难题？

2022-12-02

混凝土搅拌车的刹车片要怎样挑选合格

2022-11-14

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

搅拌车不能转动我们需要怎么处理？

所属分类：行业新闻发布时间：2021-10-20 来源：http://www.shanqijituan.com 浏览量：0

在使用到一定时间之后，过多过少的会出现拌筒不能转动，一般有3种情况：

After use for a certain period of time, the mixing drum will not rotate if there are too many or too few. Generally, there are three situations:

1、运输过程中有混泥土卡住了；

1. Concrete gets stuck during transportation;

2、液压系统或发动机发生故障；

2. Failure of hydraulic system or engine;

3、马达发生故障。

3. The motor has failed.

应对方法：

Countermeasures:

1、运输过程中有混泥土卡住了；清理干净就没有问题了；

1. Concrete gets stuck during transportation; Clean up and there will be no problem;

2、液压系统或发动机故障的处理：

2. Troubleshooting of hydraulic system or engine:

（1）打开搅拌筒检修孔盖，旋松马达上高压软管的管接头，旋转拌筒使拌筒检修孔斜向下，将砼从搅拌筒检修孔排出；
全自动上料搅拌车

(1) Open the mixing drum manhole cover, unscrew the pipe joint of the high-pressure hose on the motor, rotate the mixing drum so that the mixing drum manhole is inclined downward, and discharge the concrete from the mixing drum manhole;

（2）将故障车的高压胶管从马达上卸下，把救援用的高压胶管接上，另一端接在救援车的油泵上，并将应急用的回油管一端接在故障车的马达泄油口，回油管另一端接在救援车的油泵回油口，利用救援车来控制故障车拌筒的旋转，将砼排出。

(2) Remove the high-pressure rubber hose of the failed vehicle from the motor, connect the high-pressure rubber hose for rescue, connect the other end to the oil pump of the rescue vehicle, connect one end of the emergency oil return pipe to the motor drain port of the failed vehicle, and connect the other end of the oil return pipe to the oil return port of the oil pump of the rescue vehicle. Use the rescue vehicle to control the rotation of the mixing drum of the failed vehicle and discharge the concrete.

3、马达发生故障，处理则较简单，可把救援车的马达卸下装在故障车上，再将各个油管接好，启动救援车即可将拌筒内的砼排出。

3. In case of motor failure, the treatment is relatively simple. Remove the motor of the rescue vehicle and install it on the failed vehicle, connect each oil pipe, and start the rescue vehicle to discharge the concrete in the mixing drum.

小型混凝土搅拌车作为运输用汽车，在维护和修理方面须遵照交通部的规定，执行“定期检测、强制维护、视情修理”的维修制度。在这个大前提下，再结合混凝土搅拌运输车的实际情况，做好维护和修理。在日常维护方面，混凝土搅拌运输车除应按常规对汽车发动机、底盘等部位进行维护外，还须做好以下维护工作。

As a transport vehicle, the maintenance and repair of small concrete mixer shall comply with the provisions of the Ministry of communications and implement the maintenance system of "regular inspection, compulsory maintenance and repair as appropriate". On this premise, combined with the actual situation of concrete mixer truck, do a good job in maintenance and repair. In terms of daily maintenance, the concrete mixer truck shall not only maintain the vehicle engine, chassis and other parts according to the routine, but also do the following maintenance work.

上一页：自动上料搅拌车实心轮胎造成损坏是怎么回事？下一页：装载机式自动上料混凝土搅拌车的动力怎么样？