自上料搅拌车结构组成如按自成系统的机构来划分，它基本包括搅拌筒及其附属装置、搅拌筒的驱动装置，动力设备和运载底盘几个主要系统。下面来讲讲操作须知的五项重要内容吧。
The structural composition of self feeding mixer truck is divided according to the mechanism of its own system, which basically includes several main systems such as mixing drum and its accessories, driving device of mixing drum, power equipment and carrier chassis. Now let's talk about the five important contents of the operating instructions.
1、车辆在进行卸料的时候，若是有出现了水分蒸发，塌落度有偏低而不能够满足于客户的要求的时候，可以适量的往筒中添加水，再以10—14r/min的旋转速度在30转速之后卸料，使得混凝土能够有着比较充分的搅拌。
1. When the vehicle is unloading, if there is evaporation of water, and the slump is too low to meet the customer's requirements, an appropriate amount of water can be added to the cylinder, and then the concrete can be unloaded at a rotating speed of 10-14r/min after 30 rpm, so that the concrete can be fully mixed.
2、混凝土在进行了运输的过程里，其罐体是须禁止停动的，因为罐体停转是会导致了混凝土出现凝结的情况，在停转之后在重新启动也会对减速机和液压系统造成了一定的冲击性，会损坏了马达以及液压泵。
2. During the transportation of concrete, the tank body must not be stopped, because the tank body will cause the concrete to coagulate, and restarting after the stop will also cause a certain impact on the reducer and hydraulic system, which will damage the motor and hydraulic pump.
3、车内水箱的水量是需要时常都加注满的，以避免有不时之需。在水箱加满水之前，应该是要把放气阀打开，将箱体内的空气都放掉。在冲洗的时候要打开启发，冲洗结束或者是停止使用的时候，是需要将水关中的气体放掉的。尤其是在冬季停放的时候，供水系统以及水箱中不能够有剩的水。
3. The water tank in the car needs to be filled frequently to avoid unexpected needs. Before the water tank is filled with water, the vent valve should be opened to drain the air in the tank. The inspiration should be opened when flushing. When flushing is finished or when it is stopped, the gas in the water switch needs to be released. Especially when parking in winter, there should be no water left in the water supply system and water tank.
4、自上料搅拌车在公路上进行行驶的时候，其加长溜槽应该是要放置在卸料溜槽的支架上面并且是使用挂钩挂牢固的，不能够让挂在主排料溜槽上运作。主排料溜槽需要旋转到一个固定的位置，在拉下将其定位的手柄，将锁紧手柄瘫痪变幅机构锁起，以免防止了因为其不固定的摇摆造成了事故以及影响到了其他车辆的正常行驶。
4. When the self loading mixer is driving on the road, its lengthened chute should be placed on the support of the discharge chute and firmly hung with a hook, instead of being hung on the main discharge chute for operation. The main discharge chute needs to be rotated to a fixed position. Pull down the handle to position it and lock the locking handle to disable the luffing mechanism, so as to avoid accidents caused by its unstable swing and affecting the normal driving of other vehicles.
5、满载的混凝土正在是正转的时候若是需要反转，那么就需要操控手柄使其能够正传挺稳之后，在操控手柄让其反转。不可再进行正转的时候操控手柄让其反转。
5. If it is necessary to reverse the full load concrete when it is in forward rotation, you need to control the handle to make the forward rotation stable, and then you need to control the handle to make it reverse. When the forward rotation is no longer possible, the control handle shall be reversed.
此外车辆处于空载的驾驶过程中，搅拌筒不能够停转，以免在行驶的过程中在颠簸的时候所造成了拖轮以及滚道的磕碰使其出现了异常的损坏
In addition, when the vehicle is driving with no load, the mixing drum cannot stop, so as to avoid abnormal damage caused by collision between the tugboat and the raceway during bumping
The above is a detailed introduction to the automatic feeding mixer, and I hope it will be helpful to you. If you have any questions, please contact us. We will provide services for you with our attitude http://www.shanqijituan.com/
山汽官方微信
2022-12-23
首页
产品
电话
置顶