混凝土搅拌机应安装在坚实平整的地面上，防止因地面下陷发生倾倒。
The concrete mixer shall be installed on a solid and flat ground to prevent dumping due to ground subsidence.
在使用作业前，应按清洁、紧固、润滑、调整、防腐的程序检查机器各系统，并使之符合要求；有事故隐患必须及时。
Before operation, all systems of the machine shall be inspected according to the procedures of cleaning, fastening, lubrication, adjustment and anti-corrosion to make them meet the requirements; The hidden danger of accidents must be eliminated in time.
电力驱动的混凝土搅拌机，配电设备应安装适当的熔断器及接地装置，确保电气系统的。
For concrete mixer driven by electricity, proper fuse and grounding device shall be installed for power distribution equipment to ensure the safety of electrical system.
混凝土搅拌机运行中，请勿使砂石落入机械的运转部分中，避免零件被卡住而损坏。
During the operation of the concrete mixer, do not let the sand fall into the running part of the machine to avoid the parts being stuck and damaged.
进料斗提升起以后，料斗下严禁有人通过或停留，如必须在斗下检修时，应停机切断电源，并将进料斗用保险链挂牢后方准进行。进料斗应缓缓放下，以免下落速度太快，损坏机件或发生故障。
After lifting the hopper, no one is allowed to pass or stay under the hopper. If it is necessary to overhaul under the hopper, stop the machine, cut off the power supply and hang the hopper firmly with a safety chain. The feed hopper should be put down slowly to avoid falling too fast, damaging parts or failure.
出料前不能无故停车，更不能加料后启动，加料量不能超过规定容量。
It is not allowed to stop without reason before discharging, and it is not allowed to start after feeding, and the feeding amount shall not exceed the specified capacity.
进料斗未停稳前，不得进料。
No feeding is allowed before the feeding hopper stops stably.
混凝土搅拌机机身必须安装平稳牢固。工作前应检查离合器和制动器是否灵活可靠，钢丝绳是否断丝损坏，防护装置是否齐全可靠，并进行试运转；如搅拌筒转动平稳、不跳动、不跑偏、料斗上下和出料门转动灵活、料斗下凸轮机构正常，方可进行工作。禁止超负荷使用；机械运转中禁止用手或其他物件伸入拌和筒内去拨弄、清洗和修理等工作。
The concrete mixer body must be installed stably and firmly. Before working, check whether the clutch and brake are flexible and reliable, whether the wire rope is broken and damaged, whether the protective device is complete and reliable, and carry out trial operation; If the mixing drum rotates smoothly, does not jump, does not deviate, the hopper up and down and the discharge door rotate flexibly, the hopper under the cam mechanism is normal, the work can be carried out. Overload use is prohibited; It is forbidden to put hands or other objects into the mixing drum to fiddle, clean and repair during the operation of the machine.
当混凝土搅拌机满负荷运转中突然停电或发生故障时，应用人力将拌和筒内存料清出，然后进行检查或修理。不允许满负荷启动混凝土搅拌机，以防启动时电流过大而损坏电动机。
In case of sudden power failure or failure during full load operation of concrete mixer, the material in mixing drum shall be removed manually, and then it shall be inspected or repaired. It is not allowed to start the concrete mixer at full load to prevent the motor from being damaged due to excessive current.
操作人员如必须进入拌和筒内进行清洗或检修，应严格控制电源，以防发生意外事故。
If operators have to enter the mixing drum for cleaning or maintenance, they should strictly control the power supply to prevent accidents.
搅拌工作结束后，要及时清洗混凝土搅拌机，防止混凝土结块。清洗时，要防止电器设备受潮。清洗工作必须在断电后进行，以防止触电。
After mixing, the concrete mixer shall be cleaned in time to prevent concrete caking. When cleaning, electrical equipment should be protected from moisture. Cleaning must be carried out after power failure to prevent electric shock.
Today's automatic feeding mixer wonderful content to share with you, more wonderful content please click on our website http://www.shanqijituan.com Follow the message, there will be more wonderful content for you
山汽微信
2022-12-23
首页
产品
电话
置顶