混凝土自动上料搅拌车是将水泥，沙子，砾石骨料和水混合并将它们混合成混凝土混合物的机器。它主要由一个搅拌桶，一个给水/卸载机构，一个给水系统，一个原动机，一个传动机构，一个框架和一个支撑装置组成。只有，合理地操作设备，才能提高设备的运行性能，因此下面的编辑器将介绍设备的操作规则。
Automatic concrete loading mixer is a machine that mixes cement, sand, gravel, aggregate and water and mixes them into concrete mixture. It is mainly composed of a mixing drum, a water supply / unloading mechanism, a water supply system, a prime mover, a transmission mechanism, a frame and a support device. Only when the equipment is operated safely and reasonably can the operation performance of the equipment be improved. Therefore, the following editor will introduce the safe operation rules of the equipment.
驾驶之前，请仔细检查车辆的状况，以确保可以行驶。
Before driving, please carefully check the condition of the vehicle to ensure safe driving.
如果将混凝土自动上料搅拌车停在室外，则在装载前需要颠倒搅拌桶以排出水和碎屑，以确保混凝土的质量。
If the automatic concrete loading mixer is parked outdoors, it is necessary to reverse the mixing bucket to drain water and debris before loading to ensure the quality of concrete.
在运输混凝土时，请牢固放置倾斜的槽，以免因松动而晃动，伤害行人或影响其他行驶中的车辆的正常运行，同时避免混凝土溢出和溢出，请注意防止污染。地面。
When transporting concrete, please firmly place the inclined groove to avoid shaking due to looseness, injury to pedestrians or affecting the normal operation of other moving vehicles, and avoid concrete overflow and overflow. Please pay attention to prevent pollution. Ground.
混凝土自动上料搅拌车运输混凝土所需的时间不得超过搅拌站规定的时间。在混凝土运输过程中，请勿长时间停止搅拌桶，以防止混凝土偏析。驾驶员应不时观察具体情况，向主控室报告异常情况，并提出处理要求。
The time required for transporting concrete by automatic concrete loading mixer shall not exceed the time specified in the mixing plant. During concrete transportation, do not stop the mixing bucket for a long time to prevent concrete segregation. The driver shall observe the specific situation from time to time, report the abnormal situation to the main control room and put forward handling requirements.
如果车辆装有混凝土，则停滞时间不得超过1小时。如果超时，现场人员将不得不及时处理。
If the vehicle is equipped with concrete, the dead time shall not exceed 1 hour. In case of overtime, the on-site personnel will have to deal with it in time.
用混凝土自动上料搅拌车运输未泵送的物料时，如果温度很高，则从混凝土进入罐体到卸出为止的时间不应超过2小时，应在2小时后排放。雨中温度较低时，不应超过2.5小时。
When transporting unpumped materials with automatic concrete loading mixer, if the temperature is very high, the time from the concrete entering the tank to unloading shall not exceed 2 hours and shall be discharged after 2 hours. When the temperature in the rain is low, it shall not exceed 2.5 hours.
沥干混凝土之前，以10-12 rpm的转速旋转搅拌桶1分钟，然后沥干。
Before draining the concrete, rotate the mixing drum at 10-12 rpm for 1 minute and then drain.
卸完混凝土搅拌机后，立即使用连接到车辆的软管冲洗进料口，卸料斗和卸料斜槽，以车身上的污垢和残留的混凝土，以保持车辆的卫生。
After unloading the concrete mixer, immediately flush the feed inlet, discharge hopper and discharge chute with the hose connected to the vehicle to remove the dirt and residual concrete on the vehicle body and maintain the sanitation of the vehicle.
山汽微信
2022-12-23
首页
产品
电话
置顶